Southern Expressway, Adelaide

The expressway passing Reynella

The Adelaide Southern Veloway

The expressway is the southern part of a north–south freeway originally conceptualised under the Metropolitan Adelaide Transport Study (MATS), completed in 1965, as a freeway bypassing the city from Dry Creek to Old Noarlunga.[4] The MATS plan proved unpopular, and in 1971 all further highway construction in Adelaide was postponed for a period of ten years. In 1983 plans for a freeway north of Darlington were abandoned, and the land that had been set aside was progressively sold off.

In 1984 the state government announced plans to develop a "third arterial road" for the south. In 1987 the project was split into two phases. The first was the upgrading of Main South Road and Marion Road in the Darlington area, and the second was a new road from Darlington to Reynella. Phase one was completed in 1994 with the widening of Main South Road to eight lanes between Ayliffes Road and Seacombe Road, and the widening of Marion Road to six lanes between Main South Road and Sturt Road.

Phase 2 became the expressway, which was constructed in two stages: from Darlington to Reynella, and from Reynella to Old Noarlunga. It was developed as a one-way reversible road, with future duplication provided for in the roadworks base, to be constructed when the need arose. It used the remaining "Noarlunga Freeway" reservation, except for the northernmost kilometre, where a new route through O'Halloran Hill was chosen to provide high-quality links with Marion and Main South Roads without interfering with existing infrastructure at Sturt.

Construction of the expressway commenced in July 1995. The first stage was opened to traffic in December 1997. Construction commenced on the second stage in February 1999. It was opened to traffic in September 2001. The total cost of the reversible freeway was A$76.5m.

During its construction and for some time after its opening, the expressway was promoted via a dedicated FM radio station established by the Department of Transport, broadcasting via a low-power FM transmitter in the immediate vicinity of the road.[5] The radio station broadcast a recorded message on continuous loop featuring promotional and community information messages relating to the expressway, including a jingle that Transport Minister Diana Laidlaw declared made the expressway the only road in the world to have its own jingle.

Until August 2014, the expressway was open approximately 21 hours per day, one way for over 10 hours in each direction. The northbound (city-bound) direction occurred on weekday mornings (2:00 am – 12:30 pm) and weekend evenings (2:00 pm – 12:30 am). The southbound direction was open on weekday evenings (2:00 pm – 12:30 am) and weekend mornings (2:00 am – 12:30 pm).[6]

It was closed 12:30–2:00 am and 12:30–2:00 pm. Exceptions were Saturday and Monday mornings, when the direction remained unchanged. Weekday public holidays operated under the weekend's opening times to accommodate tourists travelling to the Fleurieu Peninsula. During each closure all road signs, lights and boom gates changed over, and the road was inspected by a tow truck contractor for debris and car breakdowns.

In 2007, the Howard government pledged $100m towards widening the expressway in its unsuccessful re-election bid.[7]

In February 2010, during the state election campaign, Premier Mike Rann announced that, if re-elected, the expressway would be duplicated in a A$445m project.[8] The inclusion of a new A$75m interchange at Darlington was later scrapped, after the government planning for a major transport hub at Darlington discovered the need for a $50 million section of road that would have to be destroyed when the expressway was eventually duplicated.[9]

Once duplication was announced in 2010, construction started in 2011. Due to the duplication of the Expressway, all of the bridges had to be widened to meet the new width of the road. Some road bridges were closed during the work needed, and others required a temporary lower speed limit for safety reasons. This caused some anger to residents and businesses.[10]

The new road was built entirely on the western side of the original roadway. It is four lanes wide between Reynella and Marion Road in the northbound. Accessibility has been improved, with completely new intersections at Beach Road and Sheriffs Road, as well as being able to left turn out at Old Noarlunga, a right turn out at Marion Road, and a left turn in at Marion Road.[11]

The expressway opened to two-way traffic in August 2014 and a cost of about A$400m.[12][13]

The Ayliffes Road bridge: The above ground road bridges were assembled on-site and moved into their final position using multi-wheeled lifters.

In 2014, the plans for an interchange at Darlington were revived and expanded to extend the Southern Expressway through Darlington.[14] The original project scope was to extend the expressway with a lowered motorway corridor. The corridor passing underneath Flinders Drive (access to Flinders University and Flinders Medical Centre), Sturt Road and a bridge connecting local streets Mimosa Terrace and Sutton Road, to the intersection of South Road, Ayliffes Road and Shepherds Hill Road with surface-level service roads and segregated cycling and pedestrian paths.[15]

The project was later revised to continue the extension past Tonsley, giving a total length of 3.3 kilometres. A road bridge, accessible from the Main South Road surface road and the lowered motorway, allows northbound traffic free-flowing access to Ayliffes Road. The associated Flinders Link Project extended the Tonsley railway line over this corridor to Flinders Medical Centre.[15]

Early works commenced late in 2014. Gateway South, a joint venture of Fulton Hogan and Laing O'Rourke was awarded the major works contract for the project in January 2016. Major works commenced in 2016 for an expected project completion in 2018,[16] later revised to December 2019.

Completion was delayed to 2020 due to sections of the lowered motorway wall collapsing.[17][18] Construction was completed and the lowered motorway fully opened to traffic in August 2020.[19][20] Final road surfacing was completed in late November through to early December 2020.

Following the 2022 South Australian state election, the incoming Malinauskas government initiated the addition of an exit at Majors Road near the top of the first climb up from the Adelaide Plains. The project was expected to cost $120 million, equally funded by state and federal governments. Completion was expected to be by the end of 2025.[21]